Tips

VEHICLE ROLL OVERS ARE MOST DANGEROUS
Properly Replaced Windshields Essential

The National Glass Association's (NGA) Coalition for Auto Glass Safety & Public Awareness (CASPA) is concerned that America's drivers have not been adequately alerted to the increasing frequency of rollover crashes and the danger these rollovers constitute to all vehicle occupants.

According to the National Highway Traffic & Safety Administration (NHTSA), a total of 10,666 people died in rollover crashes in 2002, a 5% increase from the prior year. While rollover crashes account for only 3% of all collisions, they result in 31% of the fatalities. The reason behind this grim record is the high incidence of occupant ejection and head injuries.

According to Leo Cyr, NGA Auto Glass Division Vice President, "The NGA is particularly concerned because many consumers have seen the media reports and believe the rollover danger is confined to certain sports utility vehicles (SUVs). If they don't own such a vehicle, they assume they have no need to worry. That could be a very misleading and dangerous assumption."

"It may be simple and clean to blame the vehicle or vehicle equipment manufacturer for the increased incidence of rollovers," says Cyr, "but that is the type of tunnel vision that contributes to rollovers being the growing threat to life and limb that it is. At the NGA, we absolve no one, including ourselves, from our obligation to completely and thoroughly research the rollover question and to contribute our part to its resolution."

The cost to society of rollovers is staggering. According to the NHTSA and the Insurance Institute for Highway Safety (IIHS), 9,566 passenger vehicles were involved in fatal rollover crashes in 2000 with 84% of these crashes involving only one vehicle (NHTSA). In 2001, 54% of all single-vehicle crash deaths occurred as a result of rollover crashes. In 2002, 8,768 of the 10,666 occupant deaths from rollovers occurred in single-vehicle rollover crashes. The rate of serious injury in passenger vehicle rollovers is 36% higher than in crashes where there is no rollover. (NHTSA)

Rollovers are the leading cause of fatalities in SUVs. In single vehicle crashes, 79% percent of the fatalities among SUV occupants involve rollover. Single-vehicle rollover crashes produced more than 50% of all occupant deaths in SUVs compared to 34% in pickup trucks and 19% in cars. (IIHS)

Is there an answer to reducing the carnage caused by rollovers? The NGA's Coalition for Auto Glass Safety says action is needed on many fronts. "There is no single answer or silver bullet that will cause the problem to disappear," says Cyr. "If we are serious about solving the problem, every element of the safe driving equation must become involved."

Parents, schools and media need to focus on instilling the principles of safe driving etiquette among younger drivers. All drivers, regardless of age, must recommit themselves to avoid driving aggressively. More consumer information would be helpful, especially a labeling and rollover rating system.

New safety features designed to reduce rollovers would be valuable. However, the effectiveness of existing and future safety equipment will only be as valuable as the degree to which it is used or maintained in proper working order. To this end, the states - as many have already done with mandatory seat belt legislation - must review their commitment to periodic motor vehicle inspection (PMVI). Without mandatory PMVI, the average consumer does not have the diagnostic equipment or expertise to assess their vehicle's safety preparedness.

The proper replacement of damaged windshields is precisely such a problem area. The windshield is a crucial component in preserving the structural integrity of the vehicle's passenger compartment during rollovers. If a damaged windshield is not properly replaced and becomes dislodged from the vehicle during rollover, roof crush resistance may be compromised. The result could be serious head and neck injuries; failure of the passenger side airbag to deploy properly; or, even worse, the ejection of occupants from the vehicle onto the roadway where they have no protection whatsoever.

Proper windshield replacement has evolved into a demanding science as the vehicle manufacturers' safety and structural support expectations of the windshield have increased through the years. Comprehensive technician training is essential. NGA certification of technician competency is highly recommended and is required by most responsible auto glass service providers. Currently, the NGA and CASPA are working with a number of state legislatures to require the licensing and certification of all auto glass technicians.

In the final analysis, being a well-informed consumer is probably the best protection against being a rollover statistic. "I have an SUV myself," concludes Leo Cyr. "If my SUV had an automatic pilot, I'd sure as heck blame the manufacturer if it rolled over. Until I do have auto pilot, it's up to me to protect myself and my family by knowing and not exceeding the capabilities of the vehicle. The same is true for proper windshield installation. I want to know the facts now and not when I have an accident and it's too late."

For more information on auto glass safety, you may call 1-800-CAR-HELP toll-free and select the "Damaged Auto Glass" menu option, or, visit www.glass.org/consumer/overview.htm and www.agrss.com.

Founded in 1948, the National Glass Association is the largest trade association representing the entire flat glass industry. Based in McLean, VA, NGA offers certification, education and training, and serves the industry with the leading trade publications-Glass Magazine, Window & Door, and AutoGlass. NGA currently hosts GlassBuild America: The Glass, Window & Door Expo and the National Auto Glass Conference & EXPO.